Around the World Submerged

by Edward Latimer Beach

  Kelly put his mouth to my ear and shouted back, “We’ve just gone to a hundred percent power! She’s running like a million bucks! No trouble at all!”

  I decided against asking why I had not been consulted before the speed change was made. No doubt a messenger was off looking for me at that very minute. This was Vice-Admiral Rickover’s plant and his test. My duties, clearly stated for these first trials, were to operate the ship in accordance with his directives. Besides, I, too, wanted to find out what were the actual limitations of our engines.

  Les had something more to say, which he did with a broad smile. “One more thing. That’s no power plant manual the Old Man’s got his nose into. Take a good look at the name on the cover, if you get a chance.”

  Casting a quick glance at Rickover, who appeared still engrossed in the book with the red cover, I decided to get a better look at it soon, nodded my thanks to Kelly, and began a tour of the remaining engineering spaces.

  In number two plant, all was serene. The port engine and reduction gears were spinning away with the greatest aplomb, and every bearing was cool, every critical point reading well within the specified limits.

  Lieutenant Curtis Shellman, Machinery Division Officer and presently in charge of the port engine-room watch, must have been born with the sallow complexion and dark circles under his eyes which made his normal everyday appearance that of a man under severe strain; recently he had had every right to look this way, for the main brunt of getting Triton’s engines ready for her first engineering trials had fallen upon him. Practically all of the operating machinery of the ship was under his surveillance, and the toll of many sleepless hours showed in the veritable death’s head smile he gave me by way of salutation. But there was nothing beaten down or tired about the pure and happy sense of accomplishment which showed there too, as he called my attention to the pounds of steam flow per hour, the throttle setting, the steam pressure, and the effortless RPM of the port main shaft.

  Not ordinarily given to use of the superlative, Curt essayed one this time. “She’s just wonderful, Captain!” he yelled. “I’ve never seen an engine run as smoothly as this one. Why, we could take her anywhere, anytime!” His enthusiasm was contagious, and there were corroborating nods from Chief Electrician’s Mates “L” “E” Poe (another old shipmate) and Walter O’Dell, members of the watch section.

  It was not hard to believe. What was difficult to appreciate was that Triton at this moment was driving through the water at a speed which no member of her crew had ever experienced, which we would have dismissed as insane had anyone suggested it but a few years ago, which, had this ship but come a few years sooner, might have won the war in the Pacific for us in a matter of months, instead of the years it took.

  During this time, Admiral Rickover seemed completely engrossed in his book. He rarely looked up, never changed his position, acknowledged with a brief nod Les Kelly’s shouted reports of the progress of the various tests which were being runoff.

  One of the axioms of building a power plant is that all its components must be designed with a large safety factor, for one never knows just which component, or combination of components, will prove to be the weakest element in the chain, and thus limit the power. In the Navy, Admiral Rickover’s nuclear plants were already famous for exceptional dependability. It was soon evident that the Admiral was of a mind to maintain that reputation insofar as Triton’s two-reactor plant was concerned. This was, at least, the only interpretation I could place upon his reaction to the trouble which shortly afterward developed in our starboard spring bearing.

  Since Triton’s starboard propeller is driven by the forward engine, it follows that the starboard propeller shaft must be much the longer of the two. About midway in its length, its great weight had necessitated installation of a “spring bearing”—merely a line or support bearing to keep it turning true—and it was here, in the most ordinary of standard mechanisms, that the evil little god of misfortune had decreed that difficulty should develop. The first sign of trouble was a rise in the lubricating oil temperature.

  Ordinarily, when in receipt of such a report, the immediate thing to do is slow down; but since the initial sea trials were being run by Admiral Rickover, I first sought him out to see what he desired. His red-bound book lay closed on the tool box by the de-aerating feed tank, and I found him down in the lower level of number two auxiliary machinery compartment, where the offending spring bearing was located high in the starboard after corner. When I arrived, the entire group of designers and engineers aboard for the trials were already present; and the gray-haired birdlike Admiral had climbed up into the corner for a close inspection, squeezing his wiry frame into the cramped space between the swiftly rotating propeller shaft and the curved hull of the ship, alongside the huge steel box containing the bearing.

  “We’re going to have to cut the power, Ned,” said one of the bystanders, an Electric Boat supervisor. “It’s too bad, but we can’t take a chance on wiping this bearing.”

  This was the evaluation I sensed from everyone present. The decision, however, was Rickover’s, as the officer responsible for the initial sea trials. He had evidently been listening to the bearing with a large screwdriver held against his head, and I got there just as Les Kelly handed up a stethoscope taken from one of our repair kits.

  Long minutes passed while Rickover listened at various spots on the bearing housing. There was a grim set to his jaw when he descended at last from his perch alongside the housing. “There’s not a thing wrong with the bearing,” he said shortly. “It’s working exactly as designed, but it’s not designed right.”

  “We’ve already proved the designed power of the ship, Admiral,” said the Electric Boat representative who had spoken with me. “We’ll get right on the bearing as soon as we get back to the Boat Division. I’m sure our designers can figure out what’s wrong….”

  “The only thing wrong is that it needs more cooling. Any fool can see that,” cut in Rickover. “Besides, we’re not going back. Not yet—Kelly!” Abruptly he shifted his attention to Triton’s Chief Engineer. “Rig a hose. Get a constant spray of water going on the bearing housing. Set a special watch on the lube oil temperature!”

  “But Admiral,” protested the EB man, “there’s no need to subject the bearing to additional stress. We’ve already satisfied the design specs, and there’s no point to going further …”

  Admiral Rickover’s voice held a curiously flat, monotonous tone, which I had heard before. “We’re here to find out if this ship is satisfactory for war. I’ll not let this piece of lousy designing stop the trial, and I’ll take the responsibility if it breaks down!” There was a singular lack of emphatic expression in the way Rickover spoke, effectively belied by the flinty look in his eyes.

  Within minutes, Les Kelly had a squad of his men dragging a rubber hose to the vicinity, and a spray of salt water was played upon the steel box enclosing the defective bearing and its oil supply. A constant check of the oil temperature was set up, with results reported to Admiral Rickover and, upon my private instructions to Les, to me. In the meantime, Triton had not slowed her headlong dash through the water, and after a few more minutes, to our relief, the lube oil temperature from the starboard propeller shaft spring bearing stopped its steady rise.

  We watched it carefully from this point on, and the design for a permanent “fix”—installation of the oil-cooling system which should have been there from the beginning—was complete in all essentials by the time Triton returned to the EB docks. Except for our natural concern that the temperatures continue to remain under control, the bearing gave us no further trouble, the all-out power test continued, and Admiral Rickover, with Les Kelly’s stethoscope forgotten in his pocket, went back to his tool chest and his book.

  Both Les and I were greatly heartened by the outcome of the apparent breakdown, for, like all officers attached to Triton, we wanted more than anything else to know her real ability to respond when the chips were down. Shou
ld an emergency occur, we might have need of that extra little response—perhaps sooner than any of us could then anticipate.

  As the trials progressed, the thrill of watching a magnificent engineering plant out-perform the highest expectations worked its heady magic on even Admiral Rickover. We kept every critical bearing and every mechanism under special surveillance, and maintained power, running hundreds of miles south in the process. With the over-steam-demand alarms sounding their piercing, ringing, hornlike noise throughout the vast engineering spaces, every indicator on the reactor and electric control panels touching—but not exceeding—its maximum-allowed value, the great reduction gears and turbines shrilling their joyful song of superhuman strength and dependability, Triton, deeply submerged, roared through the water with the speed of an express train.

  It is, unfortunately, not within the province of this narrative to state the speed actually achieved by our ship, nor any of the specific parameters of her power plant, but I don’t suppose there can be any objection to revealing the title of the book Vice-Admiral Rickover was reading. I had snatched a glimpse of the name on the cover when it lay temporarily unguarded on the tool box. It was The Memoirs of a Renaissance Pope.

  There are those who have claimed that the faster Triton went, the more slowly the Admiral read, and that toward the end he turned the pages very slowly indeed, if at all. As to this, I cannot testify, for I could not remain in the engine room; but my memory does record the impression, after the many hours and so very many miles, that the blank look he wore could only be a mask for his true delight.

  The trials, an unqualified success in every way, became difficult only once, as a result of my own failure to appreciate fully the forces with which we were dealing. One of the tests required that the ship be operated submerged in the astern direction. I had done this before with Piper, Amberjack, and Trigger II, but I knew very well that it might be considerably more difficult with Triton, since she was much longer and bigger, and proportionately even more slender than they. She was also infinitely more powerful, a factor which I felt would tend to equalize the situation.

  Some time after the completion of the main power trials, after a number of other evolutions had been successfully demonstrated, I directed Thamm, who was now OOD as well as Diving Officer of the Watch (the ship, deeply submerged, had no need for an officer at the periscope station in the conning tower), to reverse the engines and operate the ship astern.

  “All stop,” barked Thamm. “All back two-thirds.”

  We could feel the great bronze propellers swinging to a stop and picking up speed in the reverse direction. Our speed indicator began to slow rapidly, reached zero, where, unable to indicate reverse speeds, it stayed. Slowly we felt Triton gathering sternway, and Tom reversed the direction of action of his bow and stern planes in order to maintain correct depth. For a time all went very well, but then the ship began to oscillate with a great, slow seesaw motion, and at the same time she slowly increased depth. At first this was of no particular concern, but soon I realized that we were getting close to the ocean floor, and that a submarine of our great length could not be allowed to oscillate through very much of an angle before there might be danger of her striking bottom.

  “Sounding!” I ordered.

  The answer came back quickly. “Three hundred feet!”

  Tom looked at me but said nothing. I knew what he was thinking.

  “All stop!” I said. “All ahead two-thirds.”

  But still our speed indicator remained fixed on zero, and still our depth increased. Inexorably, we were approaching the bottom of the ocean.

  Our speed was so low that touching bottom would hardly bother Triton’s strong hull, but there was always the danger of our hitting a rock with our vulnerable propellers or the delicate sonar equipment in the bow.

  I ordered another sounding. The answer this time was two hundred feet.

  “Tom,” I said urgently, “blow all main ballast!”

  All of us watched the Ballast Control Panel, and it seemed as if everyone in the control room was also watching me. Fitzjarrald opened the blow valves on the Diving Control Panel, blew the main ballast tanks for a long minute, then stopped on Thamm’s order.

  “Blow them again,” I ordered.

  But the depth gauges continued to revolve, though more slowly. Triton had not yet reached an even keel and was now down some ten degrees by the bow. If we gathered headway in this attitude, she might ram her nose against the ocean floor.

  “All stop!” I snapped a second time, “Sounding!” And for the third time, “Blow main ballast tanks! Again!”

  “Forty feet,” called the sailor at the fathometer.

  Triton’s angle of inclination reduced, approached zero, and the depth gauge showed that the ship was rising.

  “All ahead two-thirds,” I ordered again, and heaved a sigh of relief.

  It had been a thrilling moment, one which had come upon us by surprise and which could have done damage to our new ship. Mentally, I kicked myself for not having recognized the signs earlier; we should not have allowed the ship to back for so long or the oscillations to become so severe. But all that really mattered was that damage had been averted, and as we were proceeding back to port on completion of the trials, Admiral Rickover announced to the crew that our tests were among the most successful under-way trials of a nuclear ship yet carried out.

  Altogether, there were about five days of initial sea trials before the Bureau of Ships and the Navy Department expressed themselves as satisfied. As always, a number of minor deficiencies were discovered, none of them serious. We went to sea several times more to check out one item or another until, finally, on the thirtieth of October, came what is called the Preliminary Acceptance Trials (PAT). On such occasions, a regularly constituted board of officers comes from Washington, D.C., to see whether the ship conforms to the operational standards specified when the contract was signed. The report of the trial board would decide whether General Dynamics would receive its entire fee for construction, whether any deductions for nonfulfilment of the contract were to be invoked, and whether Triton would be accepted for “unlimited service” or under some temporary restriction.

  Naturally, these trials were of considerable concern to Electric Boat, for although it was hardly likely that a ship for which all this labor and expense had been incurred would not be accepted for service, it was quite possible that some inadequacy in its construction might cost the company a great deal to correct or result in a reduction in fee.

  The PAT provided us with a welcome opportunity. Triton’s only major fault was that under certain sea conditions, in running on the surface at top speed, she took a perverse delight in driving her bow under. After a great deal of thought and careful perusal of photographs, I was sure I knew what her trouble was. Her extremely slim bow had most of its buoyant volume well aft, at precisely the point where the maximum hollow of her bow wave occurred at high speed. Thus, she lacked buoyancy exactly where needed. This was a serious deficiency, we argued. If we could add a little more buoyancy to the bow, especially in the forward part, we could greatly improve this condition. All we had to do was convince the officers from Washington that the modification was necessary.

  The trial board happened to be headed by the tallest Admiral in the Navy, known to his contemporaries and close friends as “Tiny” McCorkle. When I mentioned the problem to him, he agreed that if the situation was as I represented, something indeed should be done. I promised an adequate demonstration.

  Several hours later, with Triton making full speed through long seas sweeping from the Atlantic Ocean, I asked Admiral McCorkle if he would care to step up to the bridge. For good measure, I also invited Van Leonard, the highly competent young EB design boss who—in my estimate—could use a practical lesson in how ships behave at sea.

  Up to the bridge we went, the six-foot, six-inch Admiral awkwardly ducking his head and hunching his shoulders as he maneuvered between pipes and fittings.


  Once there, I told Dick Harris, Officer of the Deck, of my intentions. Both he and the lookouts were already heavily clothed in foul-weather gear—by design I suspect, for Dick, at least, knew what was up—and I noticed that the Quartermaster of the Watch quickly finished his business topside and headed below.

  I nodded to Dick. He reached for the bridge microphone and gave the order. “Maneuvering—bridge! Make all available speed!”

  Already at “full” speed—about half-power—Triton was riding with her bow still a foot or two out of water. Occasionally, a roll would break over the deck and sweep aft, bursting in a cascade of spray against the bottom of the sail. With the increased power, we would soon be taking considerably more water than before, and it suddenly struck me that perhaps I had not fully briefed Admiral McCorkle on what to expect. Harris and both lookouts were tightening up their parkas as I turned to him.

  “Admiral, when she drives under we’re liable to get pretty wet up here.”

  McCorkle laughed genially. “You can’t scare me, Ned,” he said. “I had my fanny wet long before you even got in the Navy.”

  The Admiral’s belt line was in the approximate vicinity of my chest, and it would have to be a pretty big wave to reach that high, but I resolved that if he could take it, I could, too. The increased drive of the engines began to be noticeable, and in a moment the first really big sea hit us. The bow spray spouted above our heads. Water dashed high over the bridge, pelting down on top of the lookouts and completely inundating Dick Harris, who stood just behind us.

  The forward part of Triton’s bridge was fitted with a transparent plastic bubble, and under this Leonard, Admiral McCorkle and I huddled for protection. There was no room for a fourth person, and the Admiral grinned at Dick’s discomfort, as he stood only a foot away. I grinned, too. There was more to come.