Astounding Science Fiction Stories: An Anthology of 350 Scifi Stories Volume 2 (Halcyon Classics)

by Various

  "Hm-m-m. Hard to count. Gap's too small. Anybody got a toothpick?"

  Nobody did.

  Jayjay turned to Jeffry Hull. "Mr. Hull, would you mind going to the lounge? I think there's some toothpicks in the snack refrigerator."

  "Sure," said Hull. "Sure."

  He pushed himself across the control room and disappeared through the stairwell.

  "Get several of them," Jayjay called after him.

  Captain Al-Amin said: "What's the trouble, Mr. Kelvin?"

  "I'm not sure yet," Jayjay answered. "When did you last have the screamer units inspected?"

  "Just before we took off from Jove Station," Al-Amin said. "That's the law. All emergency equipment has to be checked before takeoff. Why? What's the matter?"

  "Did they check this unit?" Jayjay asked doggedly.

  "Certainly. I watched them check it myself. I--" He brought himself up short and said: "Give me that torch, will you? I want to take a look at the thing."

  Jayjay handed him the flashlight and grasped the captain's belt. With one arm in a splint, Al-Amin couldn't hold the flashlight and hold on to anything solid at the same time.

  "I don't see anything wrong," he said after a minute.

  "Neither do I," Jayjay admitted. "But the way it acts--"

  "I got the toothpicks!" Jeffry Hull propelled himself across the room toward the three men who were clustered around the screamer.

  Jayjay took the toothpicks, selected one, and inserted it into the female plug. "Hard to see those threads with all the tubes blocking that plug," he said offhandedly.

  Hull said: "Captain, did you know that the refrigerator is off?"

  "Yes," said Atef Al-Amin absently. "It isn't connected to the emergency circuits. Wastes too much energy. What do you find, Mr. Kelvin?"

  After a second's silence, Jayjay said: "Let me check once more." He was running the tip of the toothpick across the threads in the female plug, counting as he did so. "Uh-huh," he said finally, "just as I thought. There's one less thread in the female plug. The male plug is stopped before it can make contact. There's a gap of about a tenth of an inch when the coupling is screwed up tight."

  "Let me see," Smith said. He took the toothpick and went through the same operation. "You're right," he said ruefully, "the female plug is faulty. We'll have to use one of the other screamers."

  "Right," said Jayjay.

  Wrong, said Fate. Or the Powers That Be, or the Fallibility of Man, whatever you want to call it.

  Every screamer unit suffered from the same defect.

  * * * * *

  "I don't understand it!" A pause. "It's impossible! Those units were tested!"

  For the first time in his life, Captain Atef Abdullah Al-Amin allowed his voice to betray him.

  Arabic is normally spoken about half an octave above the normal tone used for English. And, unlike American English, it tends to waver up and down the scale. Usually, the captain spoke English in the flat, un-accented tones of the Midwest American accent, and spoke Arabic in the ululating tones of the Egyptian.

  But now he was speaking English with an Egyptian waver, not realizing that he was doing it.

  "How could it happen? It's ridiculous!"

  The captain, his maintenance officer, and Jeffry Hull were clustered around the screamer unit in the lounge. Off to one side, Jayjay Kelvin held a deck of cards in his hands and played a game of patience called "transportation solitaire." His eyes didn't miss a play, just as his ears didn't miss a word.

  He pulled an ace from the back of the deck and flipped it to the front.

  "You said the screamers had been checked," Jeffry Hull said accusingly. "How come they weren't checked?"

  "They were!" Al-Amin said sharply.

  "Sure they were," Smith added. "I watched the check-off. There was nothing wrong then."

  "Meanwhile," Hull said, the acid bite of fear in his voice, "we have to sit here and wait for the Interplanetary Police to find us by pure luck."

  The captain should have let Hull cling to the idea that the IP could find the Persephone, even if no signal was sent. But the captain was almost as angry and flustered as Hull was.

  "Find us?" he snapped. "Don't be ridiculous! We won't even be missed until we're due at Styx, on Pluto, nine days from now. By that time, we'll be close to two billion miles beyond the orbit of Pluto. We'll never be found if we wait 'til then. Something has to be done now!" He looked at his Maintenance Officer. "Smith, isn't there some way to make contact between those two plugs?"

  "Sure," Smith said bitterly. "If we had the tools, it would be duck soup. All we'd have to do is trim down the male plug to fit the female, and we'd have it. But we don't have the tools. We've got a couple of files and a quarter-horsepower electric drill with one bit. Everything else was in the tool compartment--which is long gone, with the engine room."

  "Can't you ... uh, what do you call it? Uh ... jury-something--" Hull's voice sounded as though he were forcing it to be calm.

  "Jury-rig?" Smith said. "Yeah? With what? Dammit, we haven't got any tools, and we haven't got any materials to work with!"

  "Can't you just use a wrench to tighten them more?" Hull asked helplessly.

  Smith said a dirty word and pushed himself away from the screamer unit to glower at an unresisting wall.

  "No, Mr. Hull, we couldn't," said Captain Al-Amin with restrained patience. "That would strip the threads. If the electrical contact were made at the same time, the high-pressure oxygen-hydrogen flow would spark off, and we'd get a big explosion that would wreck everything--including us." Then he muttered to himself: "I still don't see how it could happen."

  Jayjay Kelvin pulled a nine of spades from the back of the deck to the front. It matched the four of spades that had come three cards before. Jayjay discarded the two cards between the spades. "You don't?" he asked. "Didn't you ever hear that the total is greater than the sum of its parts?"

  "What?" Captain Al-Amin sounded as though he'd been insulted--in Arabic. "What are you talking about, Mr. Kelvin?"

  "I'm talking about the idiocy of the checking system," Jayjay said flatly. "Don't you see what they did? Don't you see what happened? Each part of a screamer has to be checked separately, right?"

  Al-Amin nodded.

  "Why? Because the things burn out if you check them as a complete unit. It's like checking a .50 caliber cartridge. The only way you can check a cartridge is to shoot it in a gun. If it works, then you know it works. Period. The only trouble is that you've wasted the cartridge. You know that that one is good, but you've ruined it.

  "Same way with a screamer. If you test it as a unit, you'll ruin it. So you test it a part at a time. All the parts check out nicely because the test mechanisms are built to check each part."

  Smith squinted. "Well, sure. If you check out the whole screamer, you'll ruin it. So what?"

  "So suppose you were going to check out a cartridge," Jayjay said. "You don't fire it; you check each part separately. You check the brass case. It's all right; the tests show that it won't burst under firing pressure. You check the primer; the tests show that it will explode when hit by the gun's hammer. You check the powder; the tests show that the powder will burn nicely when the flame from the primer hits it. You check the bullet; the tests show that the slug will be expelled at the proper velocity when the powder is ignited.

  "So you assume that the cartridge will function when fired.

  "But will it?"

  "Why wouldn't it?" Smith asked.

  "Because the flame from the exploding primer can't reach the powder, that's why!" Jayjay snapped. "Some jerk has redesigned the primer so that the flame misses the propellant!"

  "How could that happen?" Hull asked blankly.

  "How? Because Designer A decided that the male plug on the screamer should have one more turn on its threads, but he forgot to tell Designer B, who designs the female plug, that the two should match. The testing equipment is designed to test each part, so each part tests out fine. The only t
rouble is that the thing doesn't test out as a whole."

  * * * * *

  Captain Al-Amin nodded slowly. "That's right. The test showed that the oxyhydrogen section worked fine. It showed that the starter worked fine. It showed that the radiowave broadcaster worked fine. But it didn't show that they'd work together."

  Smith said a short, five-letter word. It was French; the Anglo-Saxon equivalent has only four letters. "What good does all this theorizing do us?" he added. "The question is: How do we fix the thing?"

  "Well, can't you put another turn on the thread?" Hull asked.

  "Oh, sure," Smith said sarcastically. "You give me a lathe and the proper tools, and I'll make you all the connections you want. Hell, if I had the proper tools, I could turn us out a new spaceship, and we could all go home in comfort."

  "Couldn't you drill out the metal with that drill?" Hull asked plaintively.

  "No!" Smith said harshly. "How do you expect me to get a quarter-inch bit into a space less than a sixteenth of an inch in diameter?"

  Hull wasn't used to machinist's terms. "How big is an inch?"

  "Two point five four oh oh oh five centimeters," Smith said in a nasty tone of voice. "Does that help you any?"

  "I'm just trying to help!" Hull snapped. "You've got no call to get sarcastic with me!"

  Smith said the French word again.

  "Enough!" the captain barked. "Smith, control your tongue! That sort of thing won't help us." He jerked his head around. "Mr. Kelvin, do you have any suggestions?"

  Jayjay played another card. "No. Not yet. I'm thinking."

  "Smith? Any ideas?" The tone of the Arab's voice left no doubt that he meant business.

  "No, sir. Without a properly equipped machine shop, there's nothing we can do."

  "How so?"

  "Because that's a precision job, sir. The threads are tapered so that the fit will be gas-tight. That's why the threads have a ten-thousandth of an inch of soft polyethylene covering the hard steel, so that when the threads are tight, the polyethylene will act as a seal. Everything in that connection is a precision fitted job. The ends of the tubes are made to be slightly mashed together, so that the seals will be tight--they're coated with polyethylene, too. If the oxygen and hydrogen mix, the efficiency of the fuel cell goes down to zero, and you run the chance of an explosion."

  "Show me," Al-Amin said.

  Smith took a pencil out of his pocket and began drawing a cross section of the connection on the top of the nearby table.

  "Look here, captain, this is the way the two are supposed to fit. But they don't, because the male plug can't get far enough into the female socket to make the connection. Like this, see?"

  The captain nodded.

  "Well," Smith continued, "there's a thirty-second of an inch clearance there. If the female had one more turn of thread, the fit would be prefect. As it is, we get no connection. So the screamer doesn't function."

  Al-Amin looked at the drawing. "Odd that there's never been any complaint about this error before."

  Jayjay turned another ace. "Not so odd, really."

  All heads turned toward Jayjay.

  "What does that mean?" Smith asked.

  "Just what I said." Jayjay turned another card. "A screamer is supposed to call for help, isn't it? It's only used in a dire emergency. Then the only test of the whole unit comes when the occupants of the spaceship are in danger--as we are. If the things don't work, how could there be any complaint? If we can't get ours to work, will we complain? To whom?

  "How many ships have been reported missing in the past year or so? All of them presumed lost because of meteor strikes, eh? If a ship is lost and doesn't signal, we presume that it was totally destroyed. If it wasn't, they'd have signaled. As Mister Smith says: See?"

  There was a long silence.

  Jayjay Kelvin turned the last card, saw that he had lost, and began shuffling the deck.

  * * * * *

  "I think I've got it," Smith said excitedly, several hours later.

  Captain Al-Amin glanced around. Hull was dozing fitfully a few inches above the couch. Jayjay Kelvin was still methodically playing solitaire.

  "Keep your voice down," the captain ordered. "No use giving our passengers false hopes. What do you mean, you've got it?"

  "Simple. Real simple. All we have to do is file off the last thread of the male plug. Then it will fit into the female." Smith's voice was a hoarse whisper.

  "Won't work," said Jayjay Kelvin from across the room.

  Smith blew up. "How do you know?" he roared. "You sit over there making wiseacre remarks and do nothing! Play cards, that's all! What do you know about things like this, Mister Joseph Kelvin? What does a businessman know about mechanical equipment?"

  "Enough," Jayjay said quietly. "Enough to know that, if you try to file off the final thread of the male plug, you'll do an uneven job. And that will mean leakage."

  "What do you mean, an uneven job?" Smith was still furious.

  "Trimming off the end of the male plug would have to be done on a lathe," Jayjay said, without looking up from his cards. "Otherwise, the fit would be wrong, and the gases would mix. And we would all go phfft! when the mixture blew."

  Smith started to say something, but Jayjay went right on talking. "Even if we had a lathe, the male plug doesn't turn, so you'd be out of luck all the way. You can't take the screamers apart without wrecking them--not without a machine shop. You're going to have to work on that female connection. She's got a sleeve on her that will turn. Now, if--" Jayjay's voice faded off into silence, and his manipulations of the cards became purely mechanical.

  "Huh!" Smith said softly. "Just because he's related to Kelvin Associates, he thinks he's hot--" He said the French word again.

  "Is he right?" Captain Al-Amin asked sharply.

  "Well--" Smith rubbed his nose with a forefinger. "Well, yes. I was wrong. We can't do it with a file. It would have to be turned on a lathe, and we don't have a lathe. And we don't have any measuring instruments, either. This is a precision job, as I said. And we don't have a common ruler aboard, much less a micrometer. Any makeshift job will be a failure."

  Captain Al-Amin brooded over that for a moment. Then he looked at Jayjay again. "Mr. Kelvin."

  "Yes, captain?" Jayjay didn't look up from the cards in his hands.

  "Are you related to Kelvin Associates?"

  "In a way."

  Al-Amin bit at his lower lip. "Mr. Kelvin, you registered aboard this ship as Joseph Kelvin. May I ask if your middle name is James?"

  After a short pause, Jayjay said: "Yes. It is."

  "Are you the J. J. Kelvin?"

  "Yup. But I'd rather you didn't mention it when we get to Pluto."

  Smith's jaw had slowly sagged during that conversation. Then he closed his mouth with a snap. "You're Jayjay Kelvin?" he asked, opening his mouth again.

  "That's right."

  "Then I apologize."

  "Accepted," said Jayjay. He wished that Smith hadn't apologized.

  "Why didn't you say so in the first place?" Captain Al-Amin asked.

  "Because I didn't want it known that I was going to Pluto," Kelvin said. "And--after the accident happened--I kept quiet because I know human nature."

  Jeffry Hull, who had awakened during the argument, looked at Jayjay and said: "What's human nature got to do with it, Mr. Kelvin?"

  "Nothing, except that if I'd told everyone I was J. J. Kelvin, all of you would have been sitting around waiting for me to solve the problem instead of thinking about it yourselves."

  Hull nodded thoughtfully. "It makes sense, Mr. Kelvin. If they'd known that you were ... well ... Mister Spaceship Himself, they'd have let you do all the thinking. And that would have left you high and dry, wouldn't it?"

  Jayjay put the deck of cards in his pocket. "You're a pretty good sociologist, after all, Mr. Hull. You're right. Face any group with Authority--with a capital A--and they quit thinking for themselves. And if they do, then the poor slob of an Author
ity doesn't have anything to tickle his own brains, so everybody loses."

  "Well, do you have an answer?" Captain Al-Amin asked.

  Jayjay shook his head. "Not yet. I think I've got one coming up, but I wish you two would go on talking while I think."

  "I'll try," Smith said wryly.

  * * * * *

  The problem was both simple and complex. The female socket lacked one single turn of thread to make a perfect connection. A few hundredths of an inch separated success from disaster.

  Five men, including the unconscious Vandenbosch, were only a fraction of an inch away from death.

  Jayjay Kelvin listened to Smith talk for another half hour, throwing in objections when necessary, but offering no opinions.

  "All we have to do," Smith said at last, "is get rid of that little bit of metal beyond the thread in the female socket. But there's no way to get it out. We can't use a chisel because the force would warp the threads. Besides, we couldn't get a chisel in there."

  "And we don't have a chisel," Captain Al-Amin added. "We don't have any tools at all."

  "Except," said Jayjay, "an electric hand drill and a quarter-inch bit."

  "Well, sure," said Smith. "But what good will that do us?"

  "If we rigged a belt between the drill's motor and the sleeve of the female socket, the sleeve would rotate as if it were on a lathe, wouldn't it?"

  Smith blinked. "Sure. Yeah! Hey!" His face brightened. Then it looked sad again. "But what good would that do us?"

  "You said that all we have between us and success is a fraction of an inch of metal. If we can remove that fraction of an inch, we're successful."

  "But how can you put a thread into that socket?" Smith asked.

  Jayjay beamed as though it were his birthday. "We don't have to put a thread in there. All we have to do is give the thread on the male plug room to move in. All we have to do is clear away that metal. So we'll use the drill motor to turn the sleeve as if it were on a lathe."

  Smith still didn't look enthusiastic. "All right. We have a lathe. But what are we going to use for tools? What are we going to cut the metal with?"

  Jayjay's smile became broader. "Carbon steel. What else?"

  "Oh?" said Smith. "And where do we get these tools, Mr. Kelvin? From the circumambient ether?"